OEM Restraints System Part Replacement Search
2008 Volvo C30
Share:
|
Print
Print
DISABLE PROCEDURE AND TIME (Always Check Service Manual)
1. Disconnect the negative battery cable2. Warning! The supplemental
restraint system (SRS) is active for a
certain length of time after the power
supply has been disconnected. Wait
for a minimum of 3 minutes before
disconnecting or removing any SRS
components.
Vehicles with auxiliary battery:
• Warning! Make sure that the
vehicle electrical system is fully
depowered and no other power
source is connected
REV : 07/2014
PARTS THAT MUST BE REPLACED FOLLOWING A DEPLOYMENT
After activation of the driver side and/or passenger side airbags (SRS) and/or seat belt tensioners:• Replace all deployed airbags. [AIRBAG,STEERING WHEEL; AIRBAG,INSTRUMENT PNL]
• Replace all deployed seat belt tensioners, including end mountings/quickfix
• Replace the seat belt buckles corresponding to activated seat belt tensioners
• Replace the deployed pyrotechnic steering column with a new one.
After a seat airbag (SIPS) has deployed:
• Replace all deployed airbags [AIRBAG,FRONT SEAT]
• Replace the upholstery, foam and impact protection on the seats
After activation of the inflatable curtain (IC):
• Replace all deployed inflatable curtains [AIRBAG,ROOF]
• Replace all damaged components by the inflatable curtain, e.g.:
• the A panels
• the B panels
• the C panels
• the D panels
• the headlining
After whiplash system (WHIPS) deployment:
• Replace the WHIPS mechanism
When one or more airbags has deployed, the seat belt tensioners in the rear seat (and in the third row rear seat) are automatically activated. For this reason, these seat belt tensioners, the seat belt buckles and the end mountings must be replaced.
PARTS THAT MUST BE INSPECTED AND REPLACED IF DAMAGED
Where there is visible damage (deformation, cracks or material that has melted):• Steering wheel
• Contact reel [CLOCKSPRING] on the driver's airbag
• Dashboard if the passenger airbag has deployed
• The windshield and its adhesive
• Roof hatch
• All damaged wiring
• The Supplemental Restraint System
Module (SRS), see additional
information below
• WHIPS mechanism
• The loudspeakers in the dashboard
• Panels under the dashboard
• Steering column
• Remove any broken glass from the
windshield from the ventilation ducts
After a seat airbag (SIPS) deployed:
• Check that the seat and the backrest
frame on the seat are straight. This may be deformed after deployment of the airbag.
• Replace all damaged cable harnesses
After activation of the inflatable curtain (IC):
• Replace the Collision sensors on the B and C-posts [AIRBAG SENSOR,FRT DOOR; AIRBAG SENSOR,QTR PANEL]
• Replace all damaged mounting elements for the inflatable curtain and the panels.
• Replace all damaged cable harnesses
After whiplash system (WHIPS) deployment:
• Check that the seat has no other visible damage
Additional information:
Important:
• When one or more airbags have
deployed, check the seat belt tensioners in the front seats. See
Seat belt tensioner, checking . The
activation of the tensioner function
depends on whether the seat belt was in use or not when the airbag deployed.
• Supplemental Restraint System
Module (SRS) must always be replaced:
— diagnostic trouble codes (DTCs) cannot be erased
— the control module has suffered mechanical damage
— there is damage to the car floor in the area around the control module. The damage can weaken the mechanical mountings for the control module.
• If the vehicle is equipped with Volvo On Call, both the collision cable and the auxiliary battery must be checked.
• Diagnostic trouble code (DTC) SRS-112 must not be erased during the warranty period. The sensor module should be returned to Volvo in accordance with current procedures
• It should also be possible to drive the car so that the function of the steering is guaranteed
• After activation of the inflatable curtain (IC):
• Following a heavy frontal collision, it is possible that the front part of the A-post for the inflatable curtain may be damaged. Check this.
After whiplash system (WHIPS) deployment:
• Note that the WHIPS system is available in two variants
| Additional Information |
*This matrix does not currently contain all production vehicles sold in the United States. The contents were developed in cooperation with AudaExplore, a Solera company. The contents are based on the information available at the time of publication. Updates and additions will be posted as they become available. To ensure that you are using the most recent information, always refer to vehicle maker technical information.
