OEM Restraints System Part Replacement Search
2007 Jeep Wrangler
|
Share:
DISABLE PROCEDURE AND TIME (Always Check Service Manual)
1. Disconnect and isolate the battery negative cable2. Wait two minutes for the system capacitor to discharge before
further service.
REV: 03/2013
PARTS THAT MUST BE REPLACED FOLLOWING A DEPLOYMENT
When Driver Airbag has deployed:• Driver airbag [AIRBAG,STEERING WHEEL]
• Clockspring
• Steering Column Assembly including Intermediate Shaft/Coupler
• Seat belt tensioners
• All Seat Belt Retractors and Buckles in use
When Passenger Airbag has deployed:
• Passenger airbag [AIRBAG,INSTRUMENT PNL]
• Passenger Airbag Door
• Passenger Airbag Wiring Harness, or Connector if available• (•Must use Chrysler approved wire crimping tool and splices)
When Seat Airbag has deployed:
• Seat airbag [AIRBAG,FRONT SEAT]
• Seat Airbag
• Seat Back Frame
• Seat Back Foam
• Seat Back Trim Cover
• Seat Wiring Harness
The seat belt tensioners are deployed by the same signal that deploys the driver and passenger airbags and must also be replaced along with their squib connectors if either front airbag has been deployed.
PARTS THAT MUST BE INSPECTED AND REPLACED IF DAMAGED
• It is critical that the mounting surfaces and mounting brackets for the Occupant Restraint Controller (ORC), front impact sensors and side impact sensors located within the proximity of the impact damage be closely inspected and restored totheir original conditions. [MODULE,AIRBAG CONTROL; AIRBAG SENSOR,FRONT; AIRBAG SENSOR,SIDE; AIRBAG SENSOR,QTR PANEL]
• Lower anchors and tether for
children (LATCH)
• Inspect all trim panels
• Occupant Restraint Controller and mounting location
When Driver Airbag has deployed:
• Front Impact Sensors
• Steering Wheel
When Passenger Airbag has deployed:
• Instrument Panel
When Seat Airbag has deployed:
• Seat Belt Tensioners
• Side Impact Sensors
All other vehicle components should be closely inspected following any supplemental restraint component deployment, but are to be replaced only as required by the extent of the visible damage incurred.
Additional Information |
*This matrix does not currently contain all production vehicles sold in the United States. Please refer back to this page frequently to ensure the most up-to-date information. The following charts were developed in cooperation with AudaExplore, a Solera company. The contents are based on the information available at the time of publication. To ensure that the most recent information is used, always refer to the vehicle maker's technical information before working with airbags and other passive restraint systems.