OEM Restraints System Part Replacement Search


2020 Porsche Taycan

Print

DISABLE PROCEDURE AND TIME (Always Check Service Manual)

1. Switch off ignition
2. Disconnect and cover the negative terminal of the battery
3. Wait 1 minute and only then should you disconnect the plug connection.

REV: 08/2020

PARTS THAT MUST BE REPLACED FOLLOWING A DEPLOYMENT

The following components must be removed and replaced after the airbag system is triggered:

With a Triggered Airbag unit, driver's side:
1. Contact unit [CLOCK SPRING/LVR,STRG]
2. Airbag unit, driver's side. [AIRBAG,STEERING WHEEL; AIRBAG,KNEE BOLSTER]
3. Triggering unit after the system is triggered for the third time. [MODULE,AIRBAG CONTROL]
4. All airbag sensors in damaged/deformed areas of the vehicle must always be replaced. [AIRBAG SENSOR,FRONT; AIRBAG SENSOR,FRT DOOR; AIRBAG SENSOR,QTR PANEL]

The steering column must be replaced by a new or exchange unit if one of the following points applies:
1. Impact is felt by occupants.
2. Airbag has been triggered.

With a Triggered Airbag unit, passenger's side:
1. Airbag unit, passenger's side. [AIRBAG,INSTRUMENT PNL; AIRBAG,KNEE BOLSTER]
2. Triggering unit after the system is triggered for the third time. [MODULE,AIRBAG CONTROL]
3. Dashboard, Check dashboard bracket for deformation and replace if necessary
4. All airbag sensors in damaged/deformed areas of the vehicle must always be replaced. [AIRBAG SENSOR,FRONT; AIRBAG SENSOR,FRT DOOR; AIRBAG SENSOR,QTR PANEL]

With a Triggered Side-airbag unit, seat:
1. Side airbag unit, seat. [AIRBAG,FRONT SEAT; AIRBAG,REAR SEAT]
2. Seat covering, deformed seat components.
3. Triggering unit after the system is triggered for the third time. [MODULE,AIRBAG CONTROL]
4. All airbag sensors in damaged/deformed areas of the vehicle must always be replaced. [AIRBAG SENSOR,FRONT; AIRBAG SENSOR,FRT DOOR; AIRBAG SENSOR,QTR PANEL]

With a Triggered Head airbag unit:
1. Head airbag unit. [AIRBAG,ROOF]
2. Replace roof lining
3. All airbag sensors in damaged/deformed areas of the vehicle must always be replaced. [AIRBAG SENSOR,FRONT; AIRBAG SENSOR,FRT DOOR; AIRBAG SENSOR,QTR PANEL]
4. Triggering unit after the system is triggered for the third time. [MODULE,AIRBAG CONTROL]

Airbag sensor:
1. All airbag sensors in damaged/deformed areas of the vehicle must always be replaced. [AIRBAG SENSOR,FRONT; AIRBAG SENSOR,FRT DOOR; AIRBAG SENSOR,QTR PANEL]
2. Otherwise (i.e. even if the vehicle was not crashed), the airbag sensors must be replaced if they show signs of mechanical damage and/or if the airbag control unit detects that the airbag sensor is defective (use use PIWIS Tester 3 9900 to read out the fault memory).
3. Triggering unit after the system is triggered for the third time. [MODULE,AIRBAG CONTROL]

Seat-belt pretensioners:
1. All triggered belt tensioner units, front and rear.
2. Triggering unit after the system is triggered for the third time. [MODULE,AIRBAG CONTROL]

PARTS THAT MUST BE INSPECTED AND REPLACED IF DAMAGED

Steering column:
The steering column must be replaced by a new or replacement unit if one of the following points applies:
1. Visible or perceptible damage to the steering column.
2. Play in steering shaft line.
3. Fire damage.

• Airbag sensor: the airbag sensors must be replaced if they show signs of mechanical damage and/or if the airbag control unit detects that the airbag sensor is defective
(use PIWIS Tester 3 9900 to read out the fault memory).

Because it is difficult to visually determine if one or more seat-belt pretensioners has been triggered,
check the following points:
– Use PIWIS Tester 3 9900 to read out the fault memory.
– Check plug connection on the seat-belt pretensioner for damage.
– Pull out the belt strap as far as possible and check for wear.
– Perform a function test on the automatic belt device

• Always replace units that are mechanically damaged


*This matrix does not currently contain all production vehicles sold in the United States. Please refer back to this page frequently to ensure the most up-to-date information. The following charts were developed in cooperation with AudaExplore, a Solera company. The contents are based on the information available at the time of publication. To ensure that the most recent information is used, always refer to the vehicle maker's technical information before working with airbags and other passive restraint systems.


Related I-CAR Courses