OEM Restraints System Part Replacement Search
2009 Volvo V50
DISABLE PROCEDURE AND TIME (Always Check Service Manual)
1. Ignition switch off2. Disconnect the negative battery cable
3. Warning! The supplemental
restraint system (SRS) is active for a
certain length of time after the power
supply has been disconnected. Wait
for a minimum of 3 minutes before
disconnecting or removing any SRS
components.
Vehicles with auxiliary battery:
• Warning! Make sure that the
vehicle electrical system is fully
depowered and no other power
source is connected
REV: 04/2011
PARTS THAT MUST BE REPLACED FOLLOWING A DEPLOYMENT
Components that must always be replaced.After activation of the driver side and/or passenger side airbags (SRS) and/or seat belt tensioners:
• All deployed airbags [AIRBAG,STEERING WHEEL; AIRBAG,INSTRUMENT PNL]
• All deployed seat belt tensioners, including end mountings/quickfix
• Replace the seat belt buckles corresponding to activated seat belt tensioners
• Replace the pyrotechnic steering column with a new one, if deployed
• Any damaged restraint system part
After a seat airbag (SIPS) has deployed:
• All deployed airbags [AIRBAG,FRONT SEAT]
• Upholstery, foam and impact protection on the seats
• Any damaged restraint system part
After activation of the inflatable curtain (IC):
• All deployed inflatable curtains [AIRBAG,ROOF]
• Replace all damaged components by the inflatable curtain, e.g.: the A panels, the B panels, the C panels, the D panels, the headlining
• Any damaged restraint system part
After whiplash system (WHIPS) deployment:
• WHIPS mechanism
• Any damaged restraint system part
When one or more airbags has deployed, the seat belt tensioners in the rear seat (and in the third row rear seat) are automatically activated. For this reason, these seat belt tensioners, the seat belt buckles and the end mountings must be replaced.
PARTS THAT MUST BE INSPECTED AND REPLACED IF DAMAGED
Components that must be checked and replaced if necessary.Where there is visible damage (deformation, cracks or material that has melted):
• Steering wheel
• Contact reel [CLOCKSPRING] on the driver's airbag
• Dashboard if the passenger airbag has deployed
• The windshield and its adhesive
• Roof hatch
• All damaged wiring
• The Supplemental Restraint System
Module (SRS), see additional
information below
• WHIPS mechanism
• The loudspeakers in the dashboard
• Panels under the dashboard
• Steering column
• Remove any broken glass from the
windshield from the ventilation ducts
• Any restraint system part or wiring identified by diagnostic check
After a seat airbag (SIPS) deployed:
• Check that the seat and the backrest
frame on the seat are straight. This may be deformed after deployment of the airbag.
• Replace all damaged cable harnesses
• Any restraint system part or wiring identified by diagnostic check
After activation of the inflatable curtain (IC):
• Replace the Collision sensors on the B and C-posts [AIRBAG SENSOR, SIDE; AIRBAG SENSOR,QTR PANEL]
• Replace all damaged mounting elements for the inflatable curtain and the panels.
• Replace all damaged cable harnesses
• Any restraint system part or wiring identified by diagnostic check
After whiplash system (WHIPS) deployment:
• Check that the seat has no other visible damage
• Any restraint system part or wiring identified by diagnostic check
Additional information.
Important:
When one or more airbags have
deployed, check the seat belt tensioners in the front seats. See
Seat belt tensioner, checking . The
activation of the tensioner function
depends on whether the seat belt was in use or not when the airbag deployed.
Supplemental Restraint System
Module (SRS) must always be replaced:
• If the diagnostic trouble
codes (DTCs) cannot be erased
• If the control module has suffered mechanical damage
• If there is damage to the car floor in the area around the control module. The damage can weaken the mechanical mountings for the control module.
If the car is equipped with Volvo On Call check the following, both the collision cable and the auxiliary battery must be checked
Diagnostic trouble code (DTC) SRS-112 must not be erased
during the warranty period. The sensor module should be returned to Volvo in accordance with current procedures
It should also be possible to drive the
car so that the function of the steering is guaranteed
After activation of the inflatable curtain (IC):
• Following a heavy frontal collision, it is possible that the front part of the A-post for the inflatable curtain may be damaged. Check this.
After whiplash system (WHIPS) deployment:
• Note that the WHIPS system is available in two variants
| Additional Information |