OEM Restraints System Part Replacement Search
2012 Volvo S80
DISABLE PROCEDURE AND TIME (Always Check Service Manual)
The supplemental restraint system (SRS) is active for a certain length of time after the power supply has been disconnected. Wait for a minimum of 30 seconds before disconnecting or removing any SRS components.1. Turn Ignition to position one [if equipped]
2. Disconnect the negative battery cable
3. Disconnect Auxiliary battery [if equipped]
Make sure that the vehicle electrical system is fully depowered and no other power source is connected.
3. Wait for a minimum of 30 seconds before disconnecting or removing any SRS components
REV: 06/2016
PARTS THAT MUST BE REPLACED FOLLOWING A DEPLOYMENT
Components that must always be replaced.After activation of the driver side and/or passenger side airbags (SRS) and/or seat belt tensioners:
• All deployed airbags [AIRBAG,STEERING WHEEL; AIRBAG,INSTRUMENT PNL]
• All deployed seat belt tensioners, including end mountings/quickfix
• Replace the seat belt lock belonging to the deployed seat belt tensioner
• Replace the deployed pyrotechnic steering column with a new one.
After a seat airbag (SIPS) has deployed:
• All deployed airbags [AIRBAG,FRONT SEAT]
• Upholstery, foam and impact protection on the seats
After activation of the inflatable curtain (IC):
• All deployed inflatable curtains [AIRBAG,ROOF]
• Replace all damaged components by the inflatable curtain, e.g.:
• the A panels
• the B panels
• the C panels
• the D panels
• the headlining
After whiplash system (WHIPS) deployment:
• WHIPS mechanism [ELEMENT, HEADREST ADJ]
Important:
When one or more airbags has deployed, the seat belt tensioners in the rear seat (and in the third row rear seat) are automatically activated. For this reason, these seat belt tensioners, the seat belt buckles and the end mountings must be replaced.
• When one or more airbags have deployed, check the seat belt tensioners in the front seats. See Seat belt tensioner, checking. The activation of the tensioner function
depends on whether the seat belt was in use or not when the airbag deployed.
PARTS THAT MUST BE INSPECTED AND REPLACED IF DAMAGED
Components that must be checked and replaced if necessary.Where there is visible damage (deformation, cracks or material that has melted in the heat):
• Steering wheel
• Contact reel [CLOCKSPRING] on the driver's airbag
• Replace the dashboard if the passenger airbag has deployed
• The windshield and its adhesive
• Roof hatch
• All damaged wiring
• The Supplemental Restraint System Module (SRS), see section "Additional information"
• WHIPS mechanism [ELEMENT, HEADREST ADJ]
• The loudspeakers in the dashboard
• Panels under the dashboard
• Steering column
• Remove any broken glass from the windshield from the ventilation ducts
After a seat airbag (SIPS) deployed:
• Check that the seat and the backrest frame on the seat are straight. This may be deformed after deployment of the airbag.
• Replace all damaged cable harnesses
After activation of the inflatable curtain (IC):
• Replace the Collision sensors on the B and C-posts [AIRBAG SENSOR,FRT DOOR; AIRBAG SENSOR,SIDE; AIRBAG SENSOR,QTR PANEL]
• Replace all damaged mounting elements for the inflatable curtain and the panels.
• Replace all damaged cable harnesses
After whiplash system (WHIPS) deployment:
• Check that the seat has no other visible damage
Additional information:
Important:
Supplemental Restraint System Module (SRS) must always be replaced:
• If the diagnostic trouble codes (DTCs) cannot be erased
• If the control module has suffered mechanical damage
• If there is damage to the car floor in the area around the control module. The damage can weaken the mechanical mountings for the control module.
If the car is equipped with Volvo On Call check the following:
• Both the collision cable and the auxiliary battery must be checked
Diagnostic trouble code (DTC) SRS-112 must not be erased
during the warranty period. The sensor module should be returned to Volvo in accordance with current procedures
It should also be possible to drive the
car so that the function of the steering is guaranteed
After activation of the inflatable curtain (IC):
• Following a heavy frontal collision, it is possible that the front part of the A-post for the inflatable curtain may be damaged. Check this.
After whiplash system (WHIPS) deployment:
• Note that the WHIPS system is available in two variants
| Additional Information |