OEM Restraints System Part Replacement Search
2011 Volvo C70 Convertible
DISABLE PROCEDURE AND TIME (Always Check Service Manual)
1. Ignition off2. Disconnect the negative terminal
3. Wait for a minimum of 3 minutes before disconnecting or removing any SRS components.
Warning! Make sure that the vehicle electrical system is fully depowered and no other power source is connected.
REV: 07/2014
PARTS THAT MUST BE REPLACED FOLLOWING A DEPLOYMENT
After activation of the driver side and/or passenger side airbags (SRS) and/or seat belt tensioners:• Replace all deployed airbags [AIRBAG,STEERING WHEEL; AIRBAG,INSTRUMENT PNL; AIRBAG,FRONT DOOR; AIRBAG,FRONT SEAT]
• Replace all deployed seat belt tensioners, including end mountings/quickfix
• Replace the seat belt buckles corresponding to activated seat belt tensioners
• Replace the deployed pyrotechnic steering column with a new one.
After activation of the inflatable curtain (DMIC):
• Replace all deployed inflatable curtains [AIRBAG,FRONT DOOR]
• Replace all damaged components by the inflatable curtain, e.g.: the door panels
After a seat airbag
(SIPS) has deployed:
• Replace all deployed airbags [AIRBAG,FRONT SEAT]
• Replace the upholstery, foam and impact protection on the seats
After activation of roll-over protection (ROPS):
• Replace all deployed roll-over protection
• Replace all components damaged by the roll-over protection
• Replace all damaged components on the vehicle.
After whiplash system (WHIPS) deployment:
• Replace the WHIPS mechanism [ELEMENT, HEADREST ADJ]
Important:
When one or more airbags has deployed, the seat belt tensioners in the rear seat (and in the third row rear seat) are automatically activated. For this reason, these seat belt tensioners, the seat belt buckles and the end mountings must be replaced.
• When one or more airbags have deployed, check the seat belt tensioners in the front seats. See Seat belt tensioner, checking. The activation of the tensioner function
depends on whether the seat belt was in use or not when the airbag deployed.
PARTS THAT MUST BE INSPECTED AND REPLACED IF DAMAGED
Where there is visible damage (deformation, cracks or material that has melted in the heat):• Steering wheel
• Contact reel [CLOCKSPRING] on the driver's airbag
• The dashboard if the passenger airbag has deployed
• The windshield and its adhesive
• All damaged wiring
• The Supplemental Restraint System Module (SRS), see section "Additional information"
• The WHIPS mechanism [ELEMENT, HEADREST ADJ]
• The loudspeakers in the dashboard
• The panels under the dashboard
• Steering column
• Remove any broken glass from the windshield from the ventilation ducts
After activation of inflatable curtain (DMIC):
• The collision sensors at the B-pillars and the pressure sensors in the doors
• All damaged mounting elements for the inflatable curtain and the panels
• All damaged cable harnesses
• Check any components damaged by the inflatable curtain
After a seat airbag (SIPS) deployed:
• Check that the seat and the backrest frame on the seat are straight. This may be deformed after deployment of the airbag.
• Replace all damaged cable harnesses
After activation of roll-over protection (ROPS):
• The collision sensors on the B and C• pillars [AIRBAG SENSOR,FRT DOOR; AIRBAG SENSOR,QTR PANEL]
• All damaged mounting elements for the inflatable curtain and the panels
• All damaged cable harnesses
• Check any damaged components by the roll-over protection
After whiplash system (WHIPS) deployment:
• Check that the seat has no other visible damage
Additional information:
Important:
Supplemental Restraint System Module (SRS) must always be replaced:
• If the diagnostic trouble codes (DTCs) cannot be erased
• If the control module has suffered mechanical damage
• If there is damage to the car floor in the area around the control module. The damage can weaken the mechanical mountings for the control module.
If the car is equipped with Volvo On Call:
• Both the collision cable and the auxiliary battery must be checked
Diagnostic trouble code (DTC) SRS-112 must not be erased during the warranty period. The sensor module should be returned to Volvo in accordance with current procedures
It should also be possible to drive the car so that the function of the steering is guaranteed
After activation of the inflatable curtain (DMIC):
• Following a heavy frontal collision, it is possible that the front part of the A-post for the inflatable curtain may be damaged. Check this.
After whiplash system (WHIPS) deployment:
• Note that the WHIPS system is available in two variants
| Additional Information |